Maytag - S1000 - Washing machine
Manufacturer:
Image 1 of 1
If you have any other photos or manuals for the
Maytag S1000
you can
upload the files here.
Equipment:
S1000
Date:
2003
Category:
Group:
Sub Group:
Information
PRODUCT OVERVIEW
WASHER SECTION
The washer section of the S1000 is essentially the same as all of the other
washers. We have used the power unit from the deep tub washer and the
standard sized tubs to shorten the height of the washer top. A single-speed
motor is used with the Fabric-Matic system for Delicate, Regular and
Permanent Press cycles.
Low voltage relays are used for the interfacing between the computer
controls and the motor for On/Off control (run relay) and direction control
(reversing relay) for agitate and spin operations.
The water valve is a special low voltage DC version of the valve we have been
using on the standard washers. The coils are designed for operation on 24
volts direct current. Operation is direct from the computer control board and
does not require relay interfacing.
DRYER SECTION
The dryer section is a shortened-depth version of the “12” model dryers.
Using the same front and rear bulkheads as the “12” model dryers and a
“shorter” tumbler, the depth of the dryer is 21 inches overall. Drum capacity is
4.7 cubic feet. That is approximately the size of the “Halo-Of-Heat” dryers and
is a match to the washer capacity.
Internal construction is the same as the “12” model dryers and service
procedures are very similar.
As in the washer section, low voltage relays are used to interface the
computer controls with the line-voltage standard components, such as the
motor and heating element (electric models) or gas valve assembly (gas
models).
A choice of moisture sensing electronic controlled or time controlled drying is
made through touch-pad entry on the control face.
The heat input is matched to the capacity of the dryer. The electric element is
approximately 4,600 watts at 240 volts AC and the gas valve is rated at
18,000 BTU/ hour. The electric element wire is the same material and
diameter as the regular element but is shorter in overall length. The gas
valve is very similar to the regular dryer except for the location of the outlet
port and the size of the orifice. Supplied only for natural gas, it is convertible
to LP. Check your parts catalog for correct part number.
The controls system for both the washer and dryer are covered in the Cycle
Description and in the Controls Section.
1 Manual
Service manual
Manual type:
Service manual
Pages:
164
Size:
3.8 MB
Language:
english
Revision:
Manual-ID:
Date:
November 2003
Quality:
Scanned document, reading partly badly, partly not readable.
Upload date:
Jan. 5, 2019
MD5:
b6c470ee-e8f2-1b8e-91cd-ae452000b3f2
Downloads:
235